Junxia LlU，Yinping JlN，F(xiàn)engming DOU，Yushuai WANG，Yingping WANG*

1.Jilin Agricultural Science And Technology University，Jilin 132101，China；

2.Institute of Special Animal and Plant Sciences of CAAS，Changchun 130112，China

Effects of Different Decolorants on Retention Rate of Total Triterpenes in Fruit and Rattan Stems of Schisandra chinensis（Turcz.）Baill

Junxia LlU1，2，Yinping JlN2，F(xiàn)engming DOU1，Yushuai WANG2，Yingping WANG1*

1.Jilin Agricultural Science And Technology University，Jilin 132101，China；

2.Institute of Special Animal and Plant Sciences of CAAS，Changchun 130112，China

This study was to investigate the decoloration effects of activated clay，activated carbon，diatomite，Ca group bentonite，kaolin，activated aluminum oxide，magnesium oxide and attapulgite.Ultraviolet-visible spectroscopywas adopted to detect the absorbances of the extracts of Schisandra chinensis fruit and rattan stems，the contents of total triterpenoids in S.chinensis fruit and rattan stems were determined，and the decoloration rate and the retention rate of total triterpenoids of S.chinensis fruit and rattan stems were calculated.The results indicated that，attapulgite exhibited the best decoloration effect on the extract of S.chinensis fruit，with a decoloration rate up to 60.47%，activated carbon exhibited a better decoloration effect on the extract of S.chinensis rattan stems，with a decoloration rate up to 69.24%，and they had relatively higher retention rates of total triterpenoids.In the eight decolorants，attapulgite showed the best decoloration effect on the extract of S.chinensis fruit，and activated carbon exhibited the best decoloration effect on the extract of S.chinensisrattan stems.

Schisandra chinensis（Turcz.）Baill；Total triterpenoids；Decoloration；Attapulgite；Activated carbon；Retention rate

S chisandra chinensis（Turcz.）Baill contains the main components which are lignans，triterpenoids，volatile oils and polysaccharides，in which lignans are the main active components.S.chinensis has the pharmacological activities of protecting liver，inhibiting nervus centralis，and resisting oxidation，aging and tumor.In recent years，researchers have found a variety of nortriterpenoid compounds including nortriterpenoids，dinortriterpenoids， trinortriterpenoids，pentanortriterpenoids and octanortriterpenoids with novel structures and high oxidation degree subjected to skeleton rearrangement［1］.Currently，the technique for extracting effective components from S.chinensis mainly is ethanol extraction method，the extract obtained by which has low purity and high pigment content and is dull black orbrown.Therefore，decoloration is very important in the production process of plant extracts，otherwise the appearances and quality of products could be affected seriously.It is necessary to adopt physical-chemical methods to remove pigments.The methods for removing pigments mainly include adsorption method，chemical methodandmacroporousresin adsorption method.Diatomite is composed of homogeneous amorphous opal having unique pore structure with large porosity，strong adsorbability，and especially large adsorption capacity to liquid，and can serve as a filtering agent and decolorant［2］.Attapulgite clay is a kind of white powder that taking attapulgite as raw material，as well as a kind ofhydrous magnesium sili-cate mineral with a layer-chain transitional type structure，belonging to sepiolite family，having specialfibrous structure with larger specific surface area and strong adsorbability［3］.The raw ore can obtain greatly-improved adsorptive property after isolation，purification and modification，resulting in higher decolorizing ability by adsorption.Ca group bentonite is a kind of private soil widely produced in nature，and contains montmorillonite as its essential mineral which is a typical phyllosilicate of 2∶1 type having tremendous specific surface area，specific surface energy and higher cation exchange capacity and adsorbability capable of removing various harmful components（metal ions，organic matters）［4］.Kaolin is a dioctahedral phyllosilicate of 1∶1 type for which a larger specific surface area results in an larger exchange capacity，and can serve as a adsorbing material［5］.Magnesium oxide（light-burned magnesia）has stronger buffer performance（pH not higher than 9）and higher activity［6］. Activated clay is a modified bentonite product obtained from bentonite by acidation modification with inorganic acids which can improve the whiteness，specific surface area and acid strength of bentonite，having the functions of adsorption and decoloration and catalysis［7-8］.Activated carbon as one of the most ancient and most important industrial adsorbent has highlydeveloped pore structure and huge internal specific surface area，the surface of which contains （or can be added with）a variety of functional groups，and it thus has stable catalytic performance，can be used at different temperature and pH values and can be regenerated［9］.Activated aluminum oxide （r-Al2O3）is a porous and highly dispersive solid material with the characteristics of large specific surface area，good adsorption performance，acidic surface and good thermal stability，and can serve as the catalyst and catalyst support for a variety of chemical reactions［10］.In this study，the effects of above eight adsorption materials as decolorants on the retention rates of total triterpenoids in S.chinensis fruit and rattan stems were investigated，in order to select the suitable adsorbents for decoloration of extracts of S.chinensis fruit and rattan stems from them.

Materials and Methods

lnstruments

Following instruments were used: Guohua HY-2 multi-speed multi-purpose oscillator （Changzhou Guohua Electric Appliances Co.，Ltd）；PTT-A+ 100 electronic scale （Fuzhou Huazhi Scientific Instrument Co.，Ltd.）；SFTDL-5A table-top low-speed centrifuge（Shanghai Fitjar Analytic Instrument Co.，Ltd.）；HH-6 type thermostatic water bath （Changzhou Aohua Instrument Co.，Ltd.）；PS-80AJeken digital ultrasonic cleaner（Dongguan Jeken UltrasonicwaveCo.，Ltd.）；FW100 high-speed universal pulverizer（Tianjin TaisiteInstrument Co.，Ltd.）；TU-1810 ultraviolet-visible spectrophotometer（Beijing Purkinje GeneralInstrument Co.，Ltd.）；and Electro-thermostatic blast oven（Shanghai Yiheng Scientific Instruments Co.，Ltd.）.

Reagents

Oleanolicacid waspurchased from National Institute for the Control of Pharmaceutical and Biological Products. Absolute ethyl alcohol，vanillicaldehyde，glacial acetic acid，perchloric acid and concentrated sulfuric acid were analytically pure.Other reagents were as follows:food-grade activated clay（200 mesh）（Huangshan Taikeactive Bleaching Earth，Ltd.）；analytically-pure activated carbon（particle）（Tianjin Tianda Scavenging MaterialFine ChemicalFactory）；chemically-pure diatomite （Tianjin Sheng Ao Chemical Reagent Co.，Ltd.）；chemically-pure Ca group bentonite（200 mesh）（Aladdin）；chemically-pure kaolin （Sinopharm Chemical Reagent Co.，Ltd.）；chemically-pure activiated aluminum oxide（Sinopharm Chemical Reagent Co.，Ltd.）；analytically-pure magnesium oxide （light weight）（Sinopharm Chemical Reagent Co.，Ltd.）；and attapulgite （200 mesh）（Wuxi Ouwei Light Industry Science and Technology Co.，Ltd.）.

Materials

Fruit and rattan stems of S.chinensis were purchased from Tonghua Town of Jilin Province，and identified by associate professor Xu Shiquan from Medicinal Plant Research Department，Institute of Special Animal and Plant Sciences，CAAS，as dry fruit and 4-year-old rattan stems of S.chinensis，respectively.

Preparation of S.chinensis samples

Preparation of extraction solutions of S.chinensis fruit and rattan stems The Fruit and rattan stems of S.chinensis contain a variety of active components，suchaslignansand triterpenoids，which are extracted by ethanol refluxing method generally. The specific technological process including the steps of pulverizing dried ripe fruit and rattan stems of S.chinensis，sieving with a 40 mesh sieve，and drying in an oven at 50℃to constant weight；and weighing 50.0 g of S.chinensis fruit and rattan stems，respectively，adding 95%ethanol solution at a ratio of material to liquid of 1 g∶10 ml to perform reflux extraction for 3 times，and filtering to obtain filtrates，which were diluted to 500 ml，respectively.

Pretreatment of decolorants The eight decolorants（100 g for each）was soaked with 95%ethanol solution and were precipitated naturally until the supernatants were clear，and the precipitates were dried in an oven at 50℃for later use.

Decoloration method The extract（20.0 ml）of each of the fruit and rattan stems of S.chinensis was added with 5%colorant，and oscillated for 2 h.After decoloration，the corresponding filtrate was centrifuged in a centrifuge at 4 500 r/min for 10 min to obtain a supernatant.The supernatant was diluted with 95%ethanol to 20.0 ml，and then determined to obtain decoloration rates，and contents of total triterpenoids，and each treatment was repeated for three times to give a mean value.

Results and Analysis

Determination of decoloration rate

近年來，全國各地房價節節攀升，個人購房越來越向銀行住房貸款傾斜，自我國商業銀行推行個人住房貸款專項以來，已經為越來越多的人解決了住房難題。然而，個人住房貸款的增加也使得個人房貸違約的想象頻頻發生，給商業銀行帶來不小的經濟損失，已成為造成商業銀行經營風險的一部分。當前的一些商業銀行對于個人住房貸款帶來的風險問題還不夠重視，并且當前我國的個人征信系統還不夠健全，商業銀行在對個人放貸之前難以對其進行全面的信用調查，造成了商業銀行不能發現在放貸個人中存在的潛在違約風險。因此，住宅消費者個人房貸違約現象的多發給商業銀行帶來經營風險，進而有可能造成房地產金融風險。

Determination of determination wavelength With distilled water as reference，the extracts of S.chinensis fruit and rattan stems free of decoloration were scanned under 400-800 nm，and it was determined that the maximum absorption wavelengths of the extracts of S.chinensis fruit and rattan stems were 535 and 660 nm，respectively，as shown in Fig.1.

Table 1 Results of standard recovery test（n=5）

Determination ofsample decoloration rate With distilled water as reference，decolorized extracts of S.chinensis fruit and rattan stems were determined at 535 and 660 nm to obtain absorbances，respectively，for calculating decoloration rates.The calculation formula of decoloration rate is shown as following:

Decoloration rate= （D1-D2）/D1× 100%.

In which:D1represents the absorbance before decoloration；and D2represents the absorbance after decoloration.

lnvestigation of Methodology

Standard curve plotting A certain amount（1.0 mg）oleanolic acid dried to constant weight was weighed accurately to a 10 ml volumetric flask，into which absolute ethylalcoholwas added to dissolve the oleanolic acid，and the obtained solution was then diluted to constant volume and shaken to obtain 0.1 mg/ml standard solution. Certain amounts（0.2，0.4，0.6，0.8，1.0 and1.2 ml）of the standard solutions were accurately sucked into test tubes，heated in boiling water baths to vaporize ethanol and added with 50 g/L vanillic aldehyde-glacialacetic acid（0.2 ml）and perchloric acid（0.8 ml）to obtain solutions which were subjected to heating in water baths at 60℃for 15 min followed by cooling，addition of glacial acetic acid （5.0 ml）and shaking.The final solutions were determined at547 nm to obtain absorbances （D547nm）.A standard curve was constructed with the concentrations of oleanolic acid as horizontal coordinates and absorbances （D547nm）as vertical coordinates.Regression was performed to obtain a following equation:y=0.006 8x+0.009 7，r2= 0.999 1，and it was shown that there was a good linear relation between D547nmand the concentration of oleanolic acid in the range of 0-120 μg/ml（Fig.2）.

Precision test The standard solution（0.5 ml）was accurately sucked into six test tubes，respectively，and other steps were the same as the preparation of the standard curve.The obtained solutions were determined at 547 nm to obtained absorbances，the RSD value of which was 0.83%，indicating that the precision of the instruments used by this experiment was good.

Stability test The No.4 sample for the precision test was determined at 10，20，30，60，90 and 120 min to obtain D547nm，and the standard solution was stable substantially within 30 min after development，indicating the two test solutions were stable within 2 h.

Repeatability test Sixpartsof samples were weighed，respectively，to prepare test solutions which were determined，showing a RSD value of 1.96% ，indicating the method had good repeatability.

Standard recovery test Five parts of fruit and rattan stems of the same batch with known contents were accurately weighed，respectively，and were added with the same amounts of standard solutions，respectively，to prepare solutions.The recovery rates were calculated，showing RSD values of 2.75%and 2.20% ，respectively（Table 1）.

Decoloration rate and retention rates of total triterpenoids by various adsorbents

As shown in Fig.3，the decoloration effects of different decolorants on the extract of S.chinensis fruit were in the order of:attapulgite＞activated carbon＞activated aluminum oxide＞kaolin＞magnesium oxide＞diatomite＞Ca group bentonite＞activated clay（from good to bad），in which attapulgite exhibited the best decoloration effect on S.chinensis fruit，with a decoloration rate up to 60.47%，and had the highest retention rate of total triterpenoids.In fact，attapulgite not only adsorbs pigments in decoloration process，but also removes peroxides，saponins，trace metals，phosphorus，sulfide and oxidation products，and it ischeap as well［11］.Therefore，attapulgite was chosen as the decolorant for the extract of S.chinensis fruit.

As shown in Fig.4，the decoloration effects of different decolorants on the extract of S.chinensis rattan stems were in the order of:activated carbon＞diatomite＞attapulgite＞magnesium oxide＞kaolin＞activated aluminum oxide＞activated clay＞Ca group bentonite，in which activated carbon exhibited the best decoloration effect on S.chinensis rattan stems，with a decoloration rate up to 69.24%，and had a higher retention rate of total triterpenoids.

Conclusion

The results of this research indicated that，the main pigments in S.chinensis fruit were anthocyanin，etc.；the main pigment in S.chinensis rattan stems was chlorophyll；and attapulgite，activated carbon，activated aluminum oxide，kaolin，magnesium oxide，diatomite，Ca group bentonite and activated clay all had certain adsorption effects on the pigments including anthocyanin and chlorophyll.In addition，attapulgite showed the strongest adsorption effect on anthocyanin，activated carbon exhibited the strongest adsorption effect on chlorophyll，and they had relatively higher retention rates of total triterpenoids.

［1］JIN YP（金銀萍），YAN S（焉石），LIU JX（劉俊霞），et al.Research progress on cycloartane-type triterpenoids from plants ofSchisandraceae and their pharmacological effects（五味子科植物中環阿屯烷型三萜類成分及其藥理作用研究進展）［J］.Chinese Traditional and Herbal Drugs（中草藥），2014，45（4）: 582-589.

［2］XU JJ（徐建軍），ZHANG CS（張傳順），GUAN JN（管繼南）.Application and research progress of diatomite（硅藻土的應用及研究）［J］.Guangxi Journal of Light Industry（廣西輕工業），2011，27（5）: 23-24.

［3］HU T（胡濤），QIAN YH（錢運華），JIN YL（金葉玲），et al.Study on the application of attapulgite clay（凹凸棒土的應用研究）［J］.China Mining Magazine（中國礦業），2005，14（10）:73-76.

［4］ZHAO B（趙兵），WANG GQ（王國清）. Research on the adsorptive properties of bentonite to methylene blue（膨潤土對亞甲基藍的吸附性能研究）［J］.Ion Exchange and Adsorption（離子交換與吸附），2002，18（2）:156-160.

［5］CHENG HF（程宏飛），LIU QF（劉欽甫），WANG LJ（王陸軍），et al.The research progress of kaolin in china（我國高嶺土的研究進展）［J］.Geology of Chemical Minerals（化工礦產地質），2008，30（2）: 125-128.

［6］GUO RX（郭如新）.Recent progress on the applications of MgO and Mg（OH）2in environmental protection（氧化鎂、氫氧化鎂在環保領域中的應用）［J］.Jiangsu Chemical Industry（江蘇化工），2004，32（2）:1-4.

［7］JIANG GL（姜桂蘭），ZHANG PP（張培萍）.Processing and application of bentonite（膨潤土加工與應用）［M］.Beijing: Chemical Industry Press（北京:化學工業出版社），2005.

［8］WEN P（溫佩），WU WJ（武文潔），ZHAO LH（趙立輝）.Modification and application of bentonite（膨潤土的改性及應用研究進展）［J］.Technology&Development of Chemical Industry（化工技術與開發），2008，37（2）:27-31，44.

［9］CUI J（崔靜），ZHAO NQ（趙乃勤），LI JJ（李家?。?Progress in preparation of activated carbons（活性炭制備及不同品種活性炭的研究進展）［J］.Carbon Techniques（炭素技術），2005，24（1）:26-31.

［10］GUO QN（郭秋寧）.Property，preparation and application of activated aluminum oxide（活性氧化鋁的性質、制備及應用）［J］.Guangxi Chemical Industry（廣西化工），1996，25（4）:33-36.

［11］LIU YF（劉元法），WANG XG（王興國），JIN QZ（金青哲），et al.Effects of different adsorbent on pigment and trace components in oil bleaching（油脂脫色過程中吸附劑對色素及微量成分的影響）［J］.China Oils and Fats（中國油脂），2005，30（2）:25-27.

Responsible editor：Yingzhi GUANG

Responsible proofreader：Xiaoyan WU

不同脫色劑對五味子果實、藤莖中總?cè)票Ａ袈实挠绊?/p>

劉俊霞1，2，金銀萍2，竇鳳鳴1，王玉帥2，王英平1*
（1．吉林農業科技學院，吉林吉林132101；2．中國農業科學院特產研究所，吉林長春130112）

研究吸附活性白土、活性炭、硅藻土、鈣質膨潤土、高嶺土、活性氧化鋁、氧化鎂、凹凸棒土的脫色效果，采用紫外－可見分光光度法檢測五味子果實溶液、藤莖溶液吸光度，測定五味子果實、藤莖中總?cè)坪?，計算五味子果實、藤莖樣品的脫色率、總?cè)频谋Ａ袈?。結果表明，凹凸棒土對五味子果實提取液脫色效果最好，脫色率可達60.47%，活性炭對五味子藤莖提取液的脫色效果較好，脫色率達到69.24%，并且對總?cè)频谋Ａ袈氏鄬^高。8種吸附脫色劑中，凹凸棒土對五味子果實溶液脫色效果最佳，活性炭對藤莖溶液的脫色效果最佳。

五味子；總?cè)?；脫色；凹凸棒；活性炭；保留?/p>

吉林省重點科技攻關項目（20140204068YY，20140204062YY）；吉林省醫藥產業發展專項資金（YYZW201246）。

劉俊霞（1977-），女，新疆石河子人，博士研究生，主要從事中藥新藥開發與利用研究，E-mail：zyljx2007123@163.com。*通訊作者，博士生導師，研究員，主要從事藥用植物資源研究，E-mail：yingpingw@126.com。

2015-07-24

Supported by Key Science and Technology Research and Development Program of Jilin Province （20140204068YY，20140204062YY）；Special Fund for Pharmaceutical Industry Development of Jilin Province（YYZW201246）.

*Corresponding author.E-mail:yingpingw@126.com

Received:July 24，2015 Accepted:November 23，2015

修回日期 2015-11-23