趙維國 李經文 張辛亥 盧苗苗 林清松 張家亮

摘?要：東榮礦區煤層自燃現象較為嚴重，煤的氧化動力學參數是反映煤自燃傾向性的重要指標，為防治東榮礦區煤層自燃，在不同升溫速率條件下的基礎上，應用熱重分析實驗，研究了東榮煤樣升溫氧化過程中質量變化的規律，同時結合15種氣固反應機理函數，運用atava法對煤樣進行動力學分析，確定了煤氧化機理函數，及活化能、指前因子及反應級數等動力學參數，并應用Ozawa法對得到的動力學參數結果進行了驗證。實驗表明：不同升溫速率下煤樣氧化自燃總反應歷程相似，熱分析曲線的變化規律相同，但隨著升溫速度的加大，曲線有向右平移的趨勢。計算得到煤樣高溫劇烈氧化時的反應級數為1級，反應動力學模式為一級化學反應，其表觀活化能為174.588 kJ/mol，指前因子為5.729×1010.

關鍵詞：熱重實驗;特征溫度;熱分析動力學;活化能

中圖分類號：TD 752.2

文獻標志碼：A

文章編號：1672-9315（2020）02-0238-06

DOI：10.13800/j.cnki.xakjdxxb.2020.0207開放科學（資源服務）標識碼（OSID）：

Kinetics and thermal analysis of oxidation reaction of

coal samples in Dongrong mining area

ZHAO Wei-guo1，LI Jing-wen2，3，ZHANG Xin-hai2，3，

LU Miao-miao2，3，LIN Qing-song4，ZHANG Jia-liang4

（1.Institute of Mining，Liaoning Technology University，F(xiàn)uxin123000，China;

2.Key Laboratory of Western Mine Exploitation and Hazard Prevention，Ministry of Education，

Xian University of Science and Technology，Xian 710054，China;

3.College of Safety Science and Engineering，Xian University of Science and Technology，Xian710054，China;

4.Inner Mongolia Yitai Coal Co.，Ltd.，Ordos 017000，China）

Abstract：The spontaneous combustion of coal seam in Dongrong mining area is quite serious，and oxidation kinetics parameters of coal are important indicators to the tendency of spontaneous combustion of coal.In order to prevent and control spontaneous combustion of coal seam in Dongrong mining area，the law of mass change in the process of heating and oxidating of Dongrong coal sample was studied by thermogravimetric analysis experiment under different heating rate conditions.

And with 15 kinds of gas-solid reaction mechanism functions and atava in mind，the kinetic analysis of coal samples was carried out，and the mechanism function of coal oxidation and the kinetic parameters such as activation energy，pre-exponential factor and reaction series were determined.The results of the kinetic parameters obtained were verified by Ozawa method.The experimental results indicate that the total reaction process of coal sample oxidation spontaneous combustion is similar under different heating rates，and the change rule of thermal analysis curve is the same，but with the increase of heating rate，the curve has the trend of moving to the right.It is calculated that the reaction order of coal sample is first order and the reaction kinetics model is first order chemical reaction.The apparent activation energy is 174.588 kJ/mol，and the pre-exponential factor is 5.729×1010.